John Deere Z655 Oil Leak | Causes + Solution
Post Disclaimer
We independently review everything we recommend. The information is provided by John Deere Z655 Oil Leak | Causes + Solution and while we endeavour to keep the information up to date and correct, we may earn a commission if you buy something through links on our post. Learn more
If your John Deere Z655 Oil Leak, you must address the issue immediately to avoid major engine damage. Sometimes the required repair is minor and will not cost you much. An oil leak indicates a major mechanical breakdown that could signal the unit’s entire failure in some circumstances. This is why determining the source of an oil leak is so important.
John Deere Z655 Oil Leak
The crankcase or oil reservoir is likely where the oil is coming from if your lawn mower is dripping oil onto the deck. Usually, a poor seal or an overfilled oil reservoir is to blame for this. You’ll need to remove the grease, locate the source of the leak, and then proceed from there to address this issue.

Why Did John Deere Z655 Oil Leak?
Cracked Oil Seal
If you notice an oil leak on any mower model, the first thing you should check is the oil seals. The actual placement and shape of the seals will vary depending on the model of your commercial mower, but the leaky one is usually found right above the blade, beneath the engine. Purchase a replacement seal, pry the old one out, and install the new one securely. To avoid future leaks, make sure it doesn’t wrinkle or bend as you put it in.
Drain Plug
To change the oil in a John Deere mower, remove the drain cap from the bottom side of the engine and drain the old oil via the drain tube. If that cap is not correctly replaced, or if engine vibrations loosen or cause it to fall off, an oil leak from this engine section will be discovered soon. Wipe the oil from your engine and start it to see if you can find the leak source. Replace the cap properly if it emerges from the drain.
Oil Fill
An oil leak isn’t always indicative of something dangerous. When oil leaks from the region where you add oil to the engine, this is the case. To avoid producing difficulties in the oil system, always use the oil specified in your model’s owner’s manual.
When you replace the cap after putting oil on the zero-turn mower, it’s all too easy to forget to tighten it properly. Oil is kept in the engine via an O-ring seal on the opening. Before tightening the cap again, loosen it, remove the dipstick, and press the ring firmly back into place.
Cracks
Oil can also leak out of flaws or holes in your engine that aren’t supposed to be there. If there are cracks in the engine block, the engine may still function, albeit slowly, but oil will flow continuously from the system. This is likely to cause serious engine damage over time. A minor crack can sometimes be mended, but damage like this can put an engine out of commission.
Storage
If you park your mower for an extended amount of time, make sure it’s on a flat and level area. An oil leak could occur if the car is left on uneven ground. Additionally, if you check the oil while parked on a hill, the reading may be low, causing you to overfill the engine. This will result in leakage.
What Could Cause My Lawn Mower’s Engine To Leak Oil?
A lawn mower’s engine requires a continuous oil flow into the crankcase and piston. The engine is at risk of serious damage if oil seeps out of the tank or pump before it reaches the engine. If you detect an oil leak, turn off the lawnmower immediately, diagnose the situation, and repair the leak.
Causes Of Leak
Oil is stored in a reservoir near the engine. A tiny oil pump feeds oil from the reservoir to the crankcase and piston on most four-stroke lawnmowers. On the other hand, impurities in the oil might clog the reservoir and oil pump over time. Because of the vacuum pressure caused by the crankcase, the oil may find other areas to seep out with this backlog. Cracks in seals that heat and cool are another typical cause of oil spills.
Locating The Source
You must first discover the source of an oil leak in a lawnmower engine before you can stop it. Because the leak could be originating from multiple areas, locating the source can be difficult and time-consuming. Isolating the leak into one side of the engine is an excellent way to tell.
To remove any oil and grime accumulation, wipe the entire engine block with a rag and a brush. Then restart the engine for a few minutes. Stop the engine and look for any signs of oil leakage.
Leak Near Carburetor
Most lawnmower carburetors are located in the upper half of the engine, on the same side as the fuel and oil tanks. If the oil leak is around this position, the oil is likely coming from a clogged breather cavity or breather cover near the oil tank.
Remove the breather cover from the engine and wipe it clean. Clean the breathing hole with a wire to remove any oil or debris accumulation. After cleaning the gasket behind the breather cover, replace it.
Leak Near Base
If the oil leak originates near the engine’s base, it is most likely due to a problem with the oil tank or oil sump. Remove the oil dipstick from the engine and replace it securely. Check for an oil leak after restarting the engine. Remove the oil tank and sump and repair the gasket underneath if the oil leak persists. Clean the oil tank well and inspect the bottom for any minor holes.
What Causes Oil To Leak Into The Combustion Chamber?
The piston rings lose their capacity to seal against the cylinder wall as an engine age. As a result, oil can burn alongside the gasoline-air mixture in the combustion chamber.
Is It Normal For A Harley Davidson To Leak Oil?
Engine oil does not leak from Harleys. An automatic lubrication system lubricated the primary chain in the early Harleys, which drew oil from the oil pump. The extra oil flowing from the main chain case appears to be a motorbike oil leak.
Conclusion
Do you solve the John Deere Z655 Oil Leak? You are the only one who can see where the oil is coming from. If dirt obscures the source, I will use an engine degreaser to clean all the undersides and then hose it off. If everything is clean, you should be able to trace the oil back to its source.
Frequently Asked Questions
What’s wrong with my John Deere leaking oil?
If you’re going to park your mower for an extended amount of time, make sure it’s on a flat and level area. An oil leak could occur if the car is left on uneven ground. Additionally, if you check the oil while parked on a hill, the reading may be low, causing you to overfill the engine. This will result in leakage.
Why is oil seeping from the bottom of my lawnmower?
Oil may leak from a worn cylinder, especially if the seals are worn or old and damaged. Oil leaks can be caused by a crankcase air leak, a blocked or inoperative breather, or a worn-out dipstick O-ring. Leaks can be avoided by performing routine maintenance and replacing worn seals and other elements.
How can I keep the oil from leaking from my riding lawn mower?
Remove the oil dipstick from the engine and replace it securely. Check for an oil leak after restarting the engine. Remove the oil tank and sump and repair the gasket underneath if the oil leak persists. Clean the oil tank well and inspect the bottom for any minor holes.
Why is oil seeping from the carburetor of my lawnmower?
However, an oil-saturated filter can leak part of the oil around the filter box or get sucked into the carburetor, clogging the device’s internal jets and needle valves. Squeeze any remaining oil from a foam air filter or foam prefilter. Cleaning the carburetor may also be required.